10.4 Maintenance Works - Kärcher MIC D Bedienungsanleitung

10.4 Maintenance Works

10.4.1 General notes on safety
DANGER
Risk to life
When carrying out repairs, remove the vehicle from the

danger zone of passing traffic and wear reflective cloth-
ing.
WARNING
Risk of personal injury or damage!
Risk of injury due to engine overrun. Once the engine

has been switched off, wait for 5 seconds. Stay well
clear of the working area for this time.
Be careful when using high-pressure cleaners for

cleaning! Do not directly point the high-pressure jet to
electrical components, tyres, radiator fins and hydraulic
hoses.
Risk of injury when vehicle accidentally starts up. Re-

move the ignition key and disconnect the battery prior
10.4.2 Preparation
Park the vehicle on a level surface.

Bring the motor speed / hand throttle position into the

lowest position.
Turn ignition key to "STOP" and remove it.

10.4.3 Safety notes regarding the batteries
Please observe the following warning notes when handling
batteries:
Observe information
in the user manual
of the battery and on
the battery as well
as in these operat-
ing instructions!
Wear an eye shield!
Keep away children
from acid and batter-
ies!
Risk of explosion!
Fire, sparks, open
light, and smoking
not allowed!
10.4.4 Installing and connecting the battery
Insert battery in battery mount.

Screw the holder to the battery bottom.

Connect pole terminal (red cable) to positive pole (+).

Connect the pole terminal (black cable) to the negative

terminal (-).
ATTENTION
Before removing the battery, make sure that the negative
pole lead is disconnected. Check that the battery pole and
pole terminals are adequately protected with pole grease.

Risk of burns!


ATTENTION
Do not allow fluids such as motor oil, hydraulic oil, brake
fluid, diesel or coolant to enter the soil. Please protect the
environment and dispose of fluids in an environmentally
responsible way.


Follow accident prevention regulations as well as DIN VDE
0510, VDE 0105 T.1.
Danger of causti-
Risk of fire and explosion!
cization!



First aid!
Risk of injury!
Warning note!

Danger of causticization!

Disposal!


Do not throw the

battery in the
dustbin!
42
-
EN
to performing cleaning and maintenance tasks on the
vehicle.
Maintenance on the hydraulic system must only be car-
ried out by trained personnel.
CAUTION
Allow the vehicle to cool down sufficiently before per-
forming any maintenance and repair work.
Do not touch hot parts of the hydraulics, the hydrostatic
drive motor, the combustion engine and the exhaust
system.
Lock parking brake.
Note
If the motor is off, it is automatically applied.
Turn the main switch to position 0.
DANGER
Risk of explosion! Do not put tools or similar on the bat-
tery, i.e. on the terminal poles and cell connectors.
Smoking and open flames must be strictly avoided.
Rooms where batteries are charged must have good
ventilation because highly explosive gas is emitted dur-
ing charging.
WARNING
Ensure that wounds never come into contact with lead.
Always clean your hands after working on batteries.
Rinse thoroughly with lots of clear water if acid gets into
the eye or comes in contact with the skin.
Then consult a doctor immediately.
Wash off the acid If it comes in contact with the clothes.
Change clothing.
99