Intended Use; Approval; Regulations - Truma Combi D4 CP plus ready Einbauanweisung

Combi D4 CP plus ready
Table of contents
Symbols used ...................................................................... 13
Installation instructions
Intended use ........................................................................ 13
Approval .............................................................................. 13
Regulations ......................................................................... 13
Installation instructions for vehicles ................................... 14
Selecting a location ......................................................... 14
Securing the device ......................................................... 15
Exhaust and combustion air ducting ........................... 15
Permissible duct lengths ..................................................... 15
Installing the wall cowl ........................................................ 15
Extraction air supply ........................................................... 17
Circulated air intake ........................................................ 17
Warm air distribution ...................................................... 17
Fuel connection ................................................................ 18
Safety instructions for routing fuel lines ............................. 18
Installing the metering pump .............................................. 18
Fuel tank removal kit ....................................................... 19
Water connection ............................................................ 19
Installing the FrostControl (safety/drain valve) .................... 20
Water line connection / routing .......................................... 20
Room temperature sensor installation ........................ 20
Installing the control panels .......................................... 21
Electrical connections ..................................................... 21
12 V voltage supply ............................................................. 21
Room temperature sensor .................................................. 22
Control panel / air conditioning system .............................. 22
Metering pump ................................................................... 22
Extractor fan ........................................................................ 22
Initial start-up ................................................................... 22
Filling the fuel lines ............................................................. 22
Function test ..................................................................... 22
Warnings ........................................................................... 22
Symbols used
The unit must only be installed and repaired by an
expert.
Symbol indicates a possible hazard.
Note containing information and tips.
Please pay attention to the ESD regulations! Electro-
static charge can destroy the electronics. Ensure
that potential compensation is present before touching the
electronics.
Installation instructions
Read the installation instructions
carefully before commencing the work,
and then comply with them!
Disregarding safety instructions or erroneous
installation can put people in danger and cause
damage to property.
Please pay attention to the ESD regulations!

Intended use

The Combi D4 CP plus ready diesel heater is a warm-air
heater with integrated hot water boiler (10 litre volume).
This unit was designed for installation in motor homes and
caravans.
An additional altitude kit (part no. 34610-01) is required for
long periods of operation at altitudes of 1500 to 2750 m.

Approval

The heater is approved for installation in passenger vehicles
(class M1 motor homes) with a maximum of 8 seats excluding
the driver's seat, and for trailers (class O caravans).
Installation inside buses and vehicles (vehicle classes M2 and
M3) is not permitted.
The applicable regulations must be complied with when the
equipment is being installed in special vehicles and vehicles
for transporting hazardous goods.
Other forms of use are also possible after consultation with
Truma.
The year when the equipment was first taken into oper-
ation must be indicated with a cross on the type plate.

Regulations

Guarantee claims, warranty claims and acceptance of liability
will be ruled out in the event of the following:
- modifications to the unit (including accessories),
- modifications to the exhaust duct and the cowl,
- failure to use original Truma parts as replacement parts and
accessories,
- failure to follow the installation and operating instructions.
It also becomes illegal to use the appliance, and in some
countries this even makes it illegal to use the vehicle.
13