Authorized Users; Preparation By The User; Space Requirements; Foundation And Connections - Bosch VLS 5140 Originalbetriebsanleitung

en 26 | �LS ��4� | Obligations of the plant operator
�.�

Authorized users

Only users aged 18 or above who have been instructed
on how to operate the lifting platform and have proven
their ability to do so to the owner are to be entrusted
with unsupervised operation of lifting platforms. The
task of operating the lifting platform must be expressly
assigned to users by the owner. Authorization to
operate lifting platforms must be granted in writing.
Before loading a vehicle onto the lifting platform, users
should study the original operating instructions and
familiarize themselves with the operating procedures in
several trial runs.
�.4

Preparation by the user

�.4.�

Space requirements

Refer to Appendix A for the dimensions of the lifting
platform.
There must also be a clearance of at least 1 meter
between the lifting platform and fixed elements
(e.g. wall) in all lifting positions.
There must be sufficient space at the ends of the lifting
platform for driving vehicles on and off.
i
To stop vehicles colliding with the ceiling, it is
advisable to fit an overhead light barrier in low-
ceilinged buildings.
�.4.2

Foundation and connections

The user must have the following work performed
before erecting the platform:
R
Construction of the foundation following
consultation with Bosch customer service or an
authorized service agent.
R
Routing of the wiring to the installation location.
The user must provide fuse protection for the
connection.
R
Routing of the compressed air connection to the
installation location. The user must install a service
unit upstream of the connection.
i
Refer also to the corresponding information in the
commissioning instructions.
|
1 689 989 122 2012-09-13
�.�

Transportation information

The lifting platform is delivered as follows:
Packing unit Dimensions
2 x loose 500 x 70 x 30 cm
1 x disposable pallet 80 x 60 x 100 cm
The user must provide a forklift truck for internal
transport. The center of gravity and lashing points are
marked on the packaging.
Fig. 1: Center of gravity of packaging (example)
�.6

Set-up and initial commissioning

The lifting platform is only to be started up by Bosch
customer service or an authorized service agent. Initial
commissioning of the lifting platform is described in the
installation instructions. Acceptance must be performed
by a qualified person after initial commissioning.
�.7

Scope of delivery

Description
Lifting platform VLS 5140, complete
Original operating instructions
Test book
�.8

Special accessories

Information on special accessories can be obtained
from your authorized Bosch dealer.
Weight
2000 kg
Order no.
Refer to
rating plate
1 689 989 122
1 689 977 096
Robert Bosch GmbH