Installation; Installation Site; Working Conditions; Piping - ARVEN MIZAR 30 Bedienungsanweisung

7 INSTALLATION

7.1 SITE OF INSTALLATION
• Pumps marked with maximum liquid temperature (°C) which
not less than 35 °C.
• Before immersing the electropump in the pit or tank, ensure
that the place is free from sand or solid sediment.
• In case there is sediment, accurately clean the site where it
is to be placed..
• Keep the pump at least 1 mt. raised above the bottom of the
pit so that any deposits that form after installation will not be
sucked up.
• Remove the sediment periodically.
• It is very important to ensure that the water level never falls
below the body of the pump.

7.2 WORKING CONDITIONS

• Pump body always completely immersed.
• The pump cannot operate dry.
• Installation in vertical or horizontal position.
• The housing pit must be frost-free.
• Maximum depth of immersion 5 mt. (below water level).

7.3 PIPING

• Put the pump into the liquid to be pumped (Inspect for the
max. pumping height, refer to the performance curve)
• The hydraulic connection of the pump may be made with iron
or plastic parts, either rigid or flexible.
• Avoid any kind of choking of the output pipe.
• It is advisable to use pipes with an internal diameter at least
equal to that of the delivery pipe, so as to avoid a fall in the
performance of the pump and the possibility of clogging.
• For the version with a float switch, ensure that the latter can
move freely (see Paragraph 9.2. "REGULATING THE FLOAT
SWITCH").
The size of the pit must always be calculated in relation to
the quantity of incoming water and to the flow rate of
the pump so as not so subject the motor to an excessive
number of starts.
• To lower the pump, always use a rope or chain fixed be
forehand to the upper handleo on top of the pump.
NEVER USE THE POWER CABLE TO LIFT THE ELECTROPUMP.
• When using in deep wells, it is advisable to secure the power
cable to the delivery pipe with clamps, every two/three metres.
INSTRUCTIONS FOR SAFE USE:
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack experience and knowledge, unless they have been
given supervision or instruction.
• Children should be supervised to ensure that they do not play
with the appliance.
20
MIZAR
ON
OFF
REGAL
ON
OFF
SPRING
ON
OFF
DUMPER
ON
OFF