Emergency Stop - Pfaff 034554030 Betriebsanleitung

Electric Stacker with Electric Travel
English
EGV ESL EPH
4.3.5 Battery Plug - EMERGENCY-STOP
EMERGENCY - STOP
4.3.6 Warning Horn
Warning horn
4.4. Handling
4.4.1 Before taking into operation check:
Perfect function of the operating elements
−
Function of the brakes, parking- and operating brake!
−
Make a brake test!
Acid level and charging state of the battery
−
State of the travelling rollers, firm seat of the wheel screws and roller axles
−
Function of the safety button (see 4.3.2)
−
Load chains for adjustment, chain tension and wear
−
4.4.2 Driving and Braking
Close the battery connector (see 4.3.5)
−
Plug the safety key into the key-operated switch and turn to the right until it stops (see 4.3.1). The electric
−
stacker is ready for travelling and the operating elements of the lifting hydraulic may be actuated.
Bring the tie bar into driving range (see 4.3.4)
−
Control the driving direction and speed with the rotary finger lever (see 4.3.2).
−
Due to safety reasons, changing of the driving direction should only be effected from a standstill after having
−
fully braked.
Touching the safety button on the tie bar head (see 4.3.2) automatically leads to a switching to backwards
−
drive (driving direction "R"), thus providing additional protection for the operating person.
In no case may the safety button be used for shunting of the electric stacker.
−
The operating brake is to be actuated according to the respective situation. Long delay or even jerky braking
−
causes danger of accidents.
Suddenly letting of the tie bar leads to full braking (mechanical parking brake) and should be avoi-
ded. Actuating the parking brake (upper and lower tie bar position, see 4.3.5) automatically switches
off the driving current.
When leaving the stacker, take out the safety key. Bring the tie bar into upper braking position. Completely
−
lower the fork.
In case of danger - pump- or driving motor cannot be switches off - pull out the battery plug (see
4.3.5). Thus, an emergency stop of all electrically effected movements is achieved.
In current-free state, the parking brake is closed. Lowering of the fork is still possible.
Design changes under reserve!
IN CASE OF DANGER:
pump motor cannot be switched off
–
travelling motor does not switch off
–
è
DISCONNECT THE BATTERY PLUG!
The acoustic warning device can be actuated through
the push-button!
F8.1.20
page 28